Author Topic: L50 shifter stuck  (Read 1301 times)

0 Members and 1 Guest are viewing this topic.

superyota

  • Prestige Worldwide
  • Offline Silver Turtle Award
  • *
  • Turtle Points: 3
  • Male Posts: 3,354
  • Member since Oct '05
  • what happened?
    • Placer County Crawlers
L50 shifter stuck
« on: Oct 25, 2010, 11:12:30 AM »
I pulled the cover with the shift forks off of my L50 to check the gears and syncros before i installed it.  now, i put it back on, and as far as i can tell, everything is lined up, shift forks in place.  but when its all back together, the shifter doesn't move.  any ideas?
ABD Motorsports
#4475

If you can't convince them, confuse them.
Placer County Crawlers - President 2011-2016
www.placercountycrawlers.com

Rubicon Trail Foundation - Property Committee member
Friends of Fordyce - Board Member
KK6QDW

79coyotefrg

  • Rock Ninja
  • Offline Gold Turtle Award
  • *
  • Turtle Points: 1420
  • Male Posts: 22,620
  • Member since May '02
  • Solid axle Toys Rule ! ! !
    • HotSprings Superlift ORV park
Re: L50 shifter stuck
« Reply #1 on: Oct 27, 2010, 09:24:50 PM »
you have it in 2 gears remove the cover again and make sure everything is in neutral
AR-TTORA founder 22R bored.060,LCE stage II race cam http://pure-gas.org/    32/36weber, :driving: Marlin 1200 NON ceramic clutch, L52SHD+dualcase #2919, cable-locker, Yukon 5.29 gears, 35's, Allpro ebrake, front springs, and high steer, F150rears    RIP Nitro 9-29-07 :(  I sure miss him :down: MarlinCrawlerInc IS NOT affiliated with TrailGear in any way

superyota [OP]

  • Prestige Worldwide
  • Offline Silver Turtle Award
  • *
  • Turtle Points: 3
  • Male Posts: 3,354
  • Member since Oct '05
  • what happened?
    • Placer County Crawlers
Re: L50 shifter stuck
« Reply #2 on: Oct 28, 2010, 10:20:02 AM »
sorry for the stupid question, but if i spin the input shaft, and i can hold the output to where its not spinning, thats neutral, right?
ABD Motorsports
#4475

If you can't convince them, confuse them.
Placer County Crawlers - President 2011-2016
www.placercountycrawlers.com

Rubicon Trail Foundation - Property Committee member
Friends of Fordyce - Board Member
KK6QDW

superyota [OP]

  • Prestige Worldwide
  • Offline Silver Turtle Award
  • *
  • Turtle Points: 3
  • Male Posts: 3,354
  • Member since Oct '05
  • what happened?
    • Placer County Crawlers
Re: L50 shifter stuck
« Reply #3 on: Oct 28, 2010, 10:21:13 AM »
also, reverse gear was showing a little(minimal) wear on the edge.  should i change out the gear, or leave it alone?
ABD Motorsports
#4475

If you can't convince them, confuse them.
Placer County Crawlers - President 2011-2016
www.placercountycrawlers.com

Rubicon Trail Foundation - Property Committee member
Friends of Fordyce - Board Member
KK6QDW

79coyotefrg

  • Rock Ninja
  • Offline Gold Turtle Award
  • *
  • Turtle Points: 1420
  • Male Posts: 22,620
  • Member since May '02
  • Solid axle Toys Rule ! ! !
    • HotSprings Superlift ORV park
Re: L50 shifter stuck
« Reply #4 on: Oct 28, 2010, 10:43:57 AM »
sorry for the stupid question, but if i spin the input shaft, and i can hold the output to where its not spinning, thats neutral, right?
right

also, reverse gear was showing a little(minimal) wear on the edge.  should i change out the gear, or leave it alone?
leave it alone
AR-TTORA founder 22R bored.060,LCE stage II race cam http://pure-gas.org/    32/36weber, :driving: Marlin 1200 NON ceramic clutch, L52SHD+dualcase #2919, cable-locker, Yukon 5.29 gears, 35's, Allpro ebrake, front springs, and high steer, F150rears    RIP Nitro 9-29-07 :(  I sure miss him :down: MarlinCrawlerInc IS NOT affiliated with TrailGear in any way

superyota [OP]

  • Prestige Worldwide
  • Offline Silver Turtle Award
  • *
  • Turtle Points: 3
  • Male Posts: 3,354
  • Member since Oct '05
  • what happened?
    • Placer County Crawlers
Re: L50 shifter stuck
« Reply #5 on: Oct 28, 2010, 10:53:00 AM »
thanks for the info.  i'll give it a shot.
ABD Motorsports
#4475

If you can't convince them, confuse them.
Placer County Crawlers - President 2011-2016
www.placercountycrawlers.com

Rubicon Trail Foundation - Property Committee member
Friends of Fordyce - Board Member
KK6QDW

 
 
 
 
 

Related Topics

3 Replies
915 Views
Last post Jan 20, 2007, 09:19:04 PM
by BoG-ToY
33 Replies
5685 Views
Last post May 28, 2007, 12:55:28 PM
by DTB
3 Replies
2102 Views
Last post Dec 31, 2009, 05:42:51 PM
by 86toyota
21 Replies
2635 Views
Last post Mar 17, 2009, 10:33:05 AM
by Wermz84
0 Replies
908 Views
Last post Jan 29, 2010, 12:32:03 AM
by BoG-ToY